HDW Air Curtain
- Hot water coil for heating
- High pressure centrifugal fans
- Special versions available for vertical mounting
ScreenMaster HDW is the same air curtain as HD but with a hot water coil. It may be mounted either vertically besides or hung over the doorway. A special version of the hot water coil must be ordered for vertical mounting. HDW is recommendend for door heights 2,2 - 3 meters.
HDW has a hot water coil for connection to a central heating system. The output power is determined by the temperature of the water and the temperature of the inlet air. (See coil calculations for number values.) The HDW has a filter to protect the heating coil. Connection to the hot water source is done through DN 20 couplings located on top of the air curtain.
Construction
Depending on the length, the HD has either 2 or 3 centrifugal fans.
Fans and water battery and filter are mounted in a corrosion-proof
hot-dip galavanized, powder coated sheet steel casting.
Mounting
Horizontally
The HD is mounted above the inside of the gate, as near the top
of the gate as possible. The whole width of the gate should be covered.
The unit can be angled for optimum efficiency and can be recessed in
false ceilings. Make sure the inlet air grid is not blocked. Using the
supplied mounting brackets ensures enough room for the inlet air supply.
Vertically
For vertical mounting a special mounting bracket, HDS, must be ordered.
One HDS is needed for each HDWV that is mounted vertically. Due to
the total weight on the bottom HDWV, the total installation should not
exceed three units. For vertical mounting a special heating coil, should
be ordered (HDWV or HDWVL). The HDW should be mounted as close
to the opening as possible, in the door's full height. For best result the
airflow should be broken by a wall/frame on the opposite side of the door.
Operation
Regulating equipment must be ordered separately. The speed regulator
for the fan, HDR4, can control as many as 4 long or 7 short HDW air curtains.
A door switch, HDGL, can be connected to one or two HDR4 to make the air
curtain run with different speed when the door is open and when the door
is closed. Alternatively, instead of ordering two HDR4, HDR42 which has two
settings can be ordered. If only one HDR4 is used together with the door
switch the air curtain only runs when the door is open.